http://journals.lww.com/spinejournal...led.95561.aspx

Analysis of Explanted Magnetically Controlled Growing Rods from 7 UK Spinal Centers.
Joyce, Thomas J. PhD; Smith, Simon L. PhD; Rushton, Paul R.P. MRCSEd; Bowey, Andrew J. FRCS(Tr&Orth); Gibson, Michael J. FRCS
Spine: Post Acceptance: April 28, 2017
doi: 10.1097/BRS.0000000000002221
Biomechanics: PDF Only
Abstract
Study Design. Analysis of explanted MAGnetic Expansion Control (MAGEC) growing rods.

Objective. To analyze explanted MAGEC rods used in management of early onset scoliosis and identify the mode of failure in such cases.

Summary of Background Data. Magnetically controlled growing rods are increasingly used as the option of choice for early onset scoliosis. However, being more complex than conventional growing rods they are perhaps more likely to succumb to multifarious failure modes. In addition, metallosis has been reported around failed MAGEC rods.

Methods. Explanted MAGEC rods from 7 UK spinal centers were obtained for independent analysis. Thirty-four MAGEC rods, from 18 children, explanted for reasons including failure of rod lengthening and maximum rod distraction reached, were cut open to allow internal components to be evaluated and assessed.

Results. Externally, all MAGEC rods showed localized marks, which were termed 'growth marks' as they indicated growth of the rod in vivo, on the extending bar component. After cutting open, titanium wear debris was found inside all 34 (100%) MAGEC rods. Ninety-one percent (31/34) of MAGEC rods showed measurable wear of the extending bar, towards the magnet end. Substantial damage to the radial bearing was seen inside 74% (25/34) of MAGEC rods while O-ring seal failure was seen in 53% (18/34) of cases. In 44% (15/34) of MAGEC rods the drive pin was fractured but this was felt to be an effect of rod failure, not a cause.

Conclusions. The combination of high volumes of titanium wear debris alongside O-ring seal damage likely accounts for the metallosis reported clinically around some MAGEC rods. Based on this explant data, a failure mechanism in MAGEC rods due to the natural off axis loading in the spine was proposed. This is the largest data set reporting a complete analysis of explanted MAGEC rods to date.

Level of Evidence: 4

Copyright (C) 2017 Wolters Kluwer Health, Inc. All rights reserved.